Volt Key Battery

Volt Key Battery

How to Prolong Electric vehicle battery life

Lead-acid battery works Principle
 
Lead-acid battery charging and discharging of the electrochemical reaction process is the process of charging, lead sulfate to form lead oxide, lead oxide and reduction of discharge of lead sulfate. The lead sulfate crystals is a very easy matter, when the battery electrolytic solution of sulfuric acid in the concentration of lead in the static idle time is too high or too long, they will "hold a" group, to form small crystals, and attract around these small crystals lead sulfate, as the inertia of the formation of large snowball as the crystallization of lead sulfate crystals after the charge not only can not be reduced to lead oxide, but also precipitated the board attached to the electrode, resulting in a decline in working area of electrodes, this phenomenon is called sulfide, which is often said that the aging. At this time the battery capacity will gradually decrease until unusable.

Special working environment of electric bicycles

As long as lead acid batteries are used in the curing process, but other than the field of lead-acid battery electric bicycle with lead-acid batteries used on a longer life, it is because lead-acid battery electric bicycle has an easy cure work environment.

① depth of discharge
Used lead-acid batteries in the car when the one-way only in the discharge ignition, ignition battery automatically charged after the generator will not cause the battery depth of discharge. The electric bicycle can not be charged when riding, often more than 60% of the depth of discharge, deep discharge, lead sulfate concentration, sulfide would be very serious.

② large current discharge
Current electric vehicles is generally 20 km cruise 4A, this value is higher than other areas of the battery current, while speeding the work overload of the current electric cars is even greater. Battery manufacturers have been 1C charge 70%, 2C 60% of the discharge cycle life test. After such a life test can be achieved 350 charge and discharge cycle life of the battery a lot, but the actual effect will be far in the use of the. This is because the large current increase of 50% of the work of depth of discharge, the HP EliteBook 6930p Battery will accelerate curing. Therefore, the electric three-wheeled motorcycle shorter battery life because the body is too heavy three-wheeled motorcycle, working current up to 6A above.

③ high frequency discharge
Used in the field of battery backup power supply, and only during power outages will discharge, if the stop 8 times a year electricity to reach 10 years of life, only done 80 cycles charge life, and electric vehicle charge and discharge cycles a year 300 times or more are common.

④ Short Charge
Since electric bicycles are vehicles, not much time to charge, to be completed within 8 hours of 36 volt or 48 volt rechargeable 20 Ah, this must raise the charging voltage (typically 2.7 to 2.9 V single-Festival), when the charge single-cell voltage exceeds the voltage of oxygen evolution (2.35 V) or hydrogen-voltage (2.42 V), the battery will be open due to excessive oxygen evolution and the exhaust valve, causing water loss, so that the electrolyte concentration increased, the phenomenon of increasing sulfide battery .

⑤ charge after discharge can not be timely
As a transport, charging and discharging of electric bicycles are completely separated from the difficult conditions in a timely manner after discharge charge, and discharge of lead sulfate formed after a large number of hours without charge if more than half reduced to lead oxide, sulfide will form crystals .

The Charging Equipment

Widely circulated saying the industry is: the battery is not worn, it is a bad charge. In order to meet short-term electric bicycle high-capacity rechargeable battery, charging in the three-constant voltage current limit, had to constant pressure by increasing the value to 2.47V ~ 2.49V. In this way, much higher than the battery voltage of oxygen evolution at the positive plate and negative plate hydrogen evolution voltage. Some charger manufacturers of products in order to reduce the charging time of instructions, improved float switch current constant pressure, and making full power after charging indicator, there is no full power to compensate by increasing the float voltage. Thus, many of the charger float voltage than single-cell voltage 2.35V, so that a large number of oxygen evolution is still floating stage. The battery in poor oxygen circulation, so that the exhaust are constantly floating stage. High constant value to ensure that the charging time, but the sacrifice is the water loss and cure. Low constant value, and charge into the battery charging time is difficult to guarantee. The battery in improving battery grid alloy to improve the analysis of gas potential, improve oxygen circulation performance, improve the efficiency of sealed response based on the control of the maximum charging voltage 2.42V charging less, that is, hydrogen evolution potential in the following. This will inevitably lead to the extension of the charging time, which must be charged in the high current (limiting charge) of the state, adding to the polarization of the negative pulse, to improve the battery's charge acceptance in the high current charging more than filled the time Some power and reduces the charging time. 70% of the 2C charging current, battery charge acceptance is relatively large when using large current charging the HP Compaq Business Notebook 6535b Battery, damage to the battery is relatively small. Basically, the battery voltage is not higher than that of a serious hydrogen evolution. Once above the hydrogen evolution voltage, the battery will be fast water loss. The use of such chargers, must be a continuous charge and discharge a few days if the half-way stop charging, the battery will have a more serious lapse prematurely curing. And users use the battery, is no guarantee that after each use, are able to charge in time, occur several times within a year the situation is not promptly charged, the battery will be the accumulation of sulfide. Most chargers manufacturers say the depot because of the price factor does not accept the charger can guarantee the battery life. Admittedly, this is most small businesses is the case, however, for development, the scale of the large companies do not buy the expensive good charger. Some charger manufacturers to exaggerate certain features, not the effectiveness of its promotional products as well. There are many features to sell the concept of function, effectiveness is limited.

Other reasons
Many cells in the single test, it can get good results, but the battery pack for the thread, because of capacity, the open circuit voltage, state of charge, curing varying degrees, the difference will be in series with the battery pack is expanded, a single experience of the poor state of the entire group of batteries, their life significantly decreased. Cong charge the battery in the production line, to the user with car after car use this time to go through many Huanjie interval of time or even for months, in this period, as not to supplement the battery power, resulting from the discharge of lead sulfate large accumulation of crystals, the user just bought a new battery may have been reported to charge the battery and even aging. When the battery manufacturers in the implementation of quality assurance, on the recovery of the battery is not completely eliminated. After back to back the battery, the battery manufacturer to re-charge and discharge test, the test often found in more than 60% of single cells is inconsistent with the conditions of the batteries back to back. The reason for that is in series with the battery pack, the individual behind the formation of the entire set of battery cells function decline caused by the whole group back to back. Many battery manufacturers to take back to back with the battery group, pay, in addition to sulfur, packaging, again available to users to increase the effective battery life, reduce scrap, reduce some of the battery manufacturer's claim for loss of management Therefore, many dealers have already felt the battery was provided by the manufacturer, "Generations." Electric vehicle HP Compaq 6735b Battery when used properly, the general problem of the battery is not used for 3 years or so, on the contrary, greatly reduce the service life is short. Therefore, consumers daily maintenance of electric vehicle batteries electric car battery life is to determine the key.

About the Author

Professional battery shops( sales-battery.com )
Both are the retailer and wholesaler of laptop batteries,digital gamera batteries,camcorder batteries and battery chargers. These are top-quality Digital Camera Batteries at the lowest possible price available.

CANON bp-511a battery, SONY NP-FW50 battery , NIKON EN-EL14 battery,etc.

Battery,Lithium,9 Volt,Bk $11.99 BATTERY,LITHIUM,9 VOLT,BK

Rhino Battery / 12 VOLT 9Ah BATTERY / SLA9-12 $23.99 Rhino Battery - 12 VOLT 9Ah BATTERY - SLA9-12

Fein 92604030028 MultiMaster 9.6 Volt Battery $169.99 MultiMaster 9.6 Volt Battery - 92604030028

Replacement 6 Volt Battery Charger For Peg Perego $29.99 Battery Charger For 6 Volt Peg Perego Vehicles.

Replacement 12 Volt Battery Charger For Peg Perego $29.99 Battery Charger For 12 Volt Peg Perego Vehicles.

Replacement 24 Volt Battery Charger For Peg Perego $44.99 Battery Charger For 24 Volt Peg Perego Vehicles.

Peg Perego 12 Volt Battery for Ride-On Vehicles $74.99 Peg Perego 12 Volt Battery for Ride-On Vehicles

SENCO VB0108 6 Volt Ni-MH Battery $37.99 6 Volt Ni-MH Battery - VB0108

Universal / Moultrie 6 volt Battery Charger / D1724ALT6 $13.74 Universal - Moultrie 6 volt Battery Charger - D1724ALT6

E2 / 6 VOLT LITHIUM BATTERY / ENR8PDEL2CR5BP $23.78 E2 - 6 VOLT LITHIUM BATTERY - ENR8PDEL2CR5BP

Petsafe / 3 Volt Battery Module / RFA-188 $16.09 Petsafe - 3 Volt Battery Module - RFA-188

Petsafe / 3 Volt Battery Module RFA-188 / RFA-35-11 $12.33 Petsafe - 3 Volt Battery Module RFA-188 - RFA-35-11

PSUSA / Replacement Lithium Battery 3 Volt / CR2032 $10.26 PSUSA - Replacement Lithium Battery 3 Volt - CR2032

Universal / 6 volt 12ah SLA Battery / D5778ALT5 $16.99 Universal - 6 volt 12ah SLA Battery - D5778ALT5

Universal / 6 VOLT 12Ah BATTERY / D5778ALT6 $16.99 Universal - 6 VOLT 12Ah BATTERY - D5778ALT6

Zeus / 12 volt 5Ah Rechargeable Battery / PC5-12XBALT3 $16.99 Zeus - 12 volt 5Ah Rechargeable Battery - PC5-12XBALT3

PSUSA / Alkaline Battery 9 Volt / 6AM6 $10.93 PSUSA - Alkaline Battery 9 Volt - 6AM6

Petsafe / 6 Volt alkaline battery / RFA-18-11 $11.57 Petsafe - 6 Volt alkaline battery - RFA-18-11

Yuasa / 12 VOLT 1.2 Ah BATTERY / NP1.2-12ALT2 $17.99 Yuasa - 12 VOLT 1.2 Ah BATTERY - NP1.2-12ALT2

E2 / 3 VOLT LITHIUM BATTERY / EL123APBP $18.81 E2 - 3 VOLT LITHIUM BATTERY - EL123APBP

UPG / 6 Volt 4.5ah SLA Battery / UB645ALT4 $11.99 UPG - 6 Volt 4.5ah SLA Battery - UB645ALT4

Universal / 6 Volt 4.5ah SLA Battery / UB645ALT4 $11.5 Universal - 6 Volt 4.5ah SLA Battery - UB645ALT4

PSUSA / Lithium Battery 3 Volt / CR123A $19.87 PSUSA - Lithium Battery 3 Volt - CR123A

Energizer Battery / ENERGIZER 6 VOLT / 529 $24.77 Energizer Battery - ENERGIZER 6 VOLT - 529

Energizer Alkaline Battery, Lantern, 6 Volt 529 $17.05 Energizer Alkaline Battery, Lantern, 6 Volt 529

9 Volt Energizer Battery $11 Batteries We recommend high quality 9 volt alkaline batteries for your stun device. If you want the best batteries available, we have a good supply of them in stock. You can also get your AA and AAA batteries here. 9 volt Energizer battery #BAT9V

9 Volt DC Battery Tab $5.99 This 9 volt DC battery tab connects to a single 9 volt battery making this a perfect small power source for short term covert applications.

Rhino Battery / RHINO 12V 5Ah SLA Battery 12 Volt / SLA5-12 $21.99 Rhino Battery - RHINO 12V 5Ah SLA Battery 12 Volt - SLA5-12

Rhino Battery / RHINO 12V 3.4Ah SLA Battery 12 Volt / SLA3-12 $22.99 Rhino Battery - RHINO 12V 3.4Ah SLA Battery 12 Volt - SLA3-12

Rhino Battery / 6 volt 4.5 Ah Rechargeable Battery [Electronics] / SLA4-6ALT3 $13.48 Rhino Battery - 6 volt 4.5 Ah Rechargeable Battery [Electronics] - SLA4-6ALT3

Perko Compact Medium Duty Battery Selector Switch W/ Key Lock $74.99 Compact Battery Selector and Main Disconnect Switches Ignition Protected For use with 12, 24 and 32 volt marine electrical systems Higher Rating Than Popular 8500 Series Switches Same bolt patterns as popular 8500 series Smooth, positive position selector Compact, Medium Duty Battery Selector Switch w/ Key Lock

Parmak Replacement 6 Volt Battery $29.99 Parmak Replacement 6 Volt Gel Battery Replacement Battery for Parmak Solar Powered Fencers DF-SP-LI (BXF19) and DF-SP-SS Lead-Acid Gel Battery

Battery Module - 3 volt - 1 pk $9.99 Replacement 3 volt battery for PetSafe dog training collars.

Automatic 12 Volt Battery Charger $34.99 Yuasa Automatic 12 Volt Battery Charger Outperforms any wall plug charger Fully charges battery automatically Maintains full charge indefinitely Spark proof and reverse polarity protected providing mistake proof technology Always use a battery charger with a nominal output voltage that matches the nominal battery voltage. (i.e. 12 volt charger for 12 volt batteries)

6 volt alkaline battery $5.99 This 6v Alkaline Battery can be used with any equipment that requires this level power source in a battery form. This pack comes with one battery.

Dewalt Tools 18 Volt Battery. Each $98.21 Manufacturer: Dewalt Tools. Each. 40% more run-time than standard batteries Battery Voltage = 18.00 V Type = Battery Pack Customers also search for: Discount 18 Volt Battery, Buy 18 Volt Battery, Wholesale 18 Volt Battery, 028877481005, DC9096, Cordless

Perko 8504DP Medium Duty Battery Selector Switch W/ Alternator Field Disconnect And Key Lock $98.98 Medium Duty Battery Selector Switches Ignition Protected For use with 12, 24 and 32 volt marine electrical systems Capacity - 250 AMPS continuous, 360 Amp Intermittent Medium Duty Battery Selector Switch w/ Alternator Field Disconnect w Key Lock